當前位置: 首頁 > T恤資訊 > T恤,t-shirt

瀏覽歷史

T恤,t-shirt T恤批發,班衫,廣告衫設計製作,圖案印刷,diy T恤燙畫,童裝,金面T-SHIRT公司 / 2010-04-19

T恤的保養與我們身體健康息息相關

 T恤是目前市場上的暢銷服裝,因為T恤柔軟、吸汗、穿著舒適,不論男生女士,老人小孩都喜歡穿著,尤其是一些時尚的少男少女,爲追求服飾潮流,展示自身特色或個性,都樂意購買T恤服裝,多的幾十件,少的也有十件八件掛在自己的衣櫃里。在夏日時節大家可能疏忽了一件事, T恤保養與身體健康的關係:
 
穿T恤最多的季節夏季,也就是炎熱、多雨、潮濕的時節,人們把著過的T恤通過清洗、晾乾之後就放在衣櫃,可是因為T恤數量多,有好一部T恤就掛在衣櫃里好一段時間都沒動過,因空氣潮濕,掛在衣櫃內的T恤吸到水分之後,如果沒有及時拿去曬乾或烘乾,就會出現發毛生蟲;尤其是蟎蟲,最喜歡在這種潮濕、陰暗的地方繁殖生長,掛在衣櫃上的t恤它們就當成自己的 “美麗家園”,開始過著傳宗接代的如意生活。
 
因蟎蟲身體小,我們很難發現他的存在,假如有一天,你隨手拿一件掛在衣櫃T恤來著,也許蟎蟲就馬上佈滿你的全身,在你身上作為戰場,不停地咬,讓你的皮膚大面積過敏,瘙癢難忍,還有可能給你抓得發炎、紅腫,從而影響身體健康。
為解決這種問題,建議大家對自己的服裝、對自己不經常著的T恤來個科學保養,
    一.經常打開衣櫃門,讓衣櫃經常通風透氣;
  二.在衣櫃內面放一包合適大小的乾燥劑或吸濕的木炭包;
三.掛在衣櫃內的服裝不要太緊太密,
四.當你放假休息,天氣又好時,請你把T恤、服裝拿到戶外曬曬太陽,
五.拿衣服時,經常有意拍打掛在衣櫃內的其他衣服
六.衣櫃內保持整潔乾淨,穿過的服裝必須清洗、晾乾之後才放人衣櫃。
七.在衣櫃內放少許臭丸能防止蟻蟲滋生。
 
T恤設計指南
T恤是年輕人的展示個性的時尚服飾,這點朋友們早已熟知,但要設計好一件T恤, 除了在圖案上要花費大量心思之外,還要結合優良的印製技術,才能讓T恤成為當今的潮流、時尚產品。
設計一件T恤,要想到的問題很多,比如,T恤樣式,T恤面料,T恤圖案,圖案的印製工藝,等等。
T恤款式
目前,我們通常有圓領短袖,圓領長袖,V領長袖,V領短袖,反領長袖和短袖。
T恤面料
有TC(滌綸),純棉,滌棉,網孔,珠地,吸汗排氣功能布等等
面料的厚度一般採用G作為單位,也就是說每平方米布料的厚度目前有120G,145 G,160 G,180 G,190 G,200 G,220 G,300 G等等。
面料的粗細以支為單位,越粗的紗線指數越小,反之越細,常有21支,25支,32支等。
面料又分精梳和普梳,精梳是指面料做工精細,手感細膩,高檔T恤通常都是精梳棉製成。
T恤圖案
當前T恤圖案通常採用卡通形式表現,在確定主題之後,都用活潑的卡通,抽象的方式來設計,使用顏色沒有限制,甚至可以運用相片的效果
T恤圖案的尺寸要衡量T恤的尺寸來布局,T恤分為多種尺碼,XS,S,M,L,XL,XXL,XXXL,下面是T恤的尺寸對照表,設計圖案時,可根據t恤前面和背面的高度和寬度來策劃,當然,因為人的身體是橢圓型的,如果不想給手的位置擋住的話,設計的尺寸就要精確一些。
T恤圖案印製工藝
目前,市場上的T恤印花工藝很多,絲印,燙印,蠟印,植絨印花,貼亞克力片,粘膠等等;絲印又分為水漿,膠漿,發泡漿,等等,燙印又分為冷轉移,熱轉印等工藝,總之,方式繁多,效果也各有不同。
在設計T恤時,必須事先考慮到印製工藝種種技術和效果。
 T恤絲印
絲印T恤,就是把油墨通過帶孔的網布把圖案印到T恤的面料上面,但這個過程很複雜,也涉及到很多生產製作工序流程;
1.繃網,製作T恤絲印版,首先是要有一個網框,把150T的絲網布張緊在網板上,如印製A4尺寸的圖案,網框的內徑尺寸每邊都比圖案大6-10cm。
2.製版,製版是把設計好的圖案或文字,通過電腦和感光技術將稿件轉變成菲林,有了菲林,就在繃好的網版上通過紫外線光源,把圖案刻在絲網板上,首先是清洗網布,用洗潔精把網布清洗乾淨,并晾乾,把感光漿倒在上漿具均勻的塗布在網版上,烘乾后,把菲林緊貼在網吧背面,通過感光箱進行適當時間的曝光,然後用清水沖洗,印T恤的圖案就刻在了網板上,通過烘乾,印刷T恤的網版就完成了。
3,有了網版,我們的T恤印刷就可開始了,首先把網版的四邊用膠紙封住,一方油墨參透到面料上弄賍T恤,用蝴蝶夾夾住網版上頭,固定版位,印檯上鋪上T恤,將網版圖案與T恤的位置對準,油墨倒入網版,用刮刀張勻油墨,從遠到近的用力推行刮刀,圖案印到了T恤上。T恤絲印完成!
 燙印T恤
燙印T恤,就是把設計好的圖案,通過熱轉印機,印壓在T恤的上。
1,把T恤圖案設計稿通過印刷機印在轉印紙上,
2,把印好的轉印圖案準確的放在鋪平的T恤上,
3,用恒溫好180度左右熱壓板壓住圖案約2分鐘,移走熱壓板,撕掉轉印紙,燙印T恤成功。
 
T恤燙印技術的幾個問答
T恤燙印是當今印刷行業較為流行的印製工藝,因為能在T恤或其他物體上印製出相片效果,很受消費者青睞,尤其是印製禮品T恤,瓷杯等小批量的產品,都很受歡迎。下麵是幾個技術上的問答,請能作為參考,不對之處,請多指正。
 一,T恤轉印有沒有印上去沒有手感的熱轉印紙
有,要用到熱昇華墨水,和噴墨轉印紙。印出來的效果有幾點要注意的
      1:取決於用墨水的品質,好的墨水在溫度,紙和時間都符合的情況下效果還原是特別好的,
      2:紙,其實一般的噴繪打印紙就可以,但如果要效果好的話還有其他進口的,效果還原特別好,但也有缺點,墨打上去以後不容易幹,還有就是出壓紙輪印。但效果肯定沒的說。
     3,時間:要把握好時間,一般在1分鐘左右吧,還有壓力調合適了
.熱轉印紙和熱昇華紙有什麼區別分別印在什麼上面
答:熱轉印紙和熱昇華紙的區別應該是後者是前者的一種,都叫熱轉印紙,熱昇華很有局限性,我的經驗它只限于含滌成分很高的布料上還必須是白色,才能出效果。其他的熱轉印紙應用就很普遍了,T恤面料基本上都可以吧,但一般的皮革面料是印不上的。熱轉印紙的用法主要區別在是印深色T恤還是淺色T恤上面。
熱轉印要用什麼墨水,是用什麼轉印墨水,還是湯畫墨水用那種用在T恤印畫上面好,用什麼牌子的
答:這個問題可以看出來你對這東西還很懂,你問得其實是一樣的東西,至於墨水的選用根據你針對的客戶來取決,差異挺大的,印深色衣服和淺色衣服的墨水是不一樣的,價格差別也不少,國產的有很多,但顏色還原的不好,我用過一種日本的,是印淺色衣服的(其實淺色就是指白色,昇華墨水)六塊多一毫升。
四、熱轉印紙有的分什麼冷撕、熱撕
AW的那種最好印出來品質最好我的經驗中你問的好想只是針對於淺色衣服的熱轉印紙。當然是熱斯的好,冷撕的到冷了以後特別難揭,沒准還能把顏色揭掉。
五、熱轉印怎麼組合出來效果最好.
取決於你想花多少錢了,你所問的問題基本上就是想印個性T恤了,很簡單,一台電腦,一個燙畫機,一台EPSON印表機,基本上就OK了,買點淺色熱轉印紙和噴墨打印紙,熱昇華墨水,就可以幹了。能做的範圍:白色T恤都可以印,金屬牌,還可以印旗,球衣(當然只限之前說的白色的含滌成分較高的,其實就是熱昇華這兩項前面的印金屬牌也算是熱昇華)
六、分別報一下紙和顏料的價格
印白色T恤的紙熱撕的好像是在20塊錢一張吧,特別好揭,冷撕的便宜。印熱昇華的紙就是噴墨打印紙,一包一百張,也就幾兩百多塊錢吧,好點的二十塊錢一張,顏色還原的特別好。墨水原來幹的時候是日本進口的,10塊一毫升,
 
 
 
 
The T-shirt is closely related to our health maintenance
 
The T-shirt is currently on the market popular clothing, because the T-shirt soft, absorb sweat, wear comfortable, whether boys ladies, the old man child like wearing, especially some fashionable pursuit for girls, dress, their characteristics and personality, willing to buy more clothes, the T-shirt, little also several ten pieces eight in his closet. In the summer season you may neglect one thing, t-shirts, maintenance and healthy relationships:
 
Wear a T-shirt, most of the season is summer heat, rainy season, moist, people have the T-shirt through cleaning, drying on chest, but after a T-shirt, because good a T-shirt is hanging in the closet, a period of time, not because of the air inside the closet hanging in damp, t-shirts to moisture, if not timely to dry or dry, can appear wool insect, Especially in the most like mite, damp, dark place grow, hang on chest T-shirt they as his "beautiful homeland," began to live the life breed.
 
Because of our hard body, mites, if he found one, you take a hanging in the wardrobe T-shirt, perhaps mite right your whole body is in you as a battlefield, kept biting, let your skin allergy, urticant painful area, and may give you have inflammation, swelling, thereby affecting the body healthy.
To solve this problem, suggestion on their costumes, to oneself not often the T-shirt for a scientific maintenance, a chest door open. Often, let the closet often ventilated breathe freely,
2 in the closet. Put a pack of concave size of dry or wet absorption of charcoal bag,
3 within the chest. Hanging garments don't too tight too close,
Four. When you have to rest, the weather was good, please take a T-shirt, clothing to get out in the sun,
Five. When the clothes, often deliberately flap in other chest hang clothes
Within six. Chest, neat and clean clothes must be cleaned, through after drying only one chest.
7. In a closet is put inside can prevent naphthalene cow bug.
 
T-shirt design guidelines
The T-shirt is the young people personality of fashion show that already familiar friends, but to design a T-shirt, except on design thoughts will cost a lot, but also the combination of fine printing technology, can let a T-shirt, fashionable products.
Design a T-shirt, to think of the many problems, such as, t-shirts, t-shirts, fabrics, design, design of the T-shirt printing technology, etc.
T-shirt design
At present, we usually have a short-sleeved, a long-sleeved, v-neck long-sleeved, V, lead long and short sleeve short sleeve.
T-shirts fabrics
Have the TC (polyester cotton, polyester-cotton), meshes, beads, absorbent cloth exhaust function, etc
The thickness of the fabrics commonly used as a unit, i.e. G per square meters of cloth thickness, 145 120G currently have 160, 180, g. g. g., 190 G, 200 G, 220 G, 300 G, etc.
The degree of fabric, yarn index of the thicker the smaller, and the fine, 21, 25, 32 teams, etc.
Fabric and combed with comb, combed refers to handle delicate do manual work is careful, fabrics, high-grade T-shirt is usually combed cotton.
T-shirt design
The T-shirt design usually adopts the cartoon form, in determining the theme, with lively cartoon, abstract way to design, use color without limitation, can even use photographs
The size of the T-shirt design to measure the size of the T-shirt for layout, t-shirts, various sizes, divided, m., "S XS, XL, XXL L, below is the XXXL size, the size of the T-shirt design table, can according to the front and back of the T-shirt height and width to planning, of course, because the person's body is elliptic, if want to place the size of the block, design is accurate.
T-shirt design printing technology
At present, the market T-shirt printing, printing, stamping, wax printing, printing, flocking, viscose etc; yakeli Printing and divided into water slurry, mucilage, foaming, etc, and divided into cold stamping process and heat transfer, anyhow, various ways, the effect also vary.
In designing a T-shirt, must consider printing process various technology and effect.
 
 
T-shirt printing
The T-shirt printing ink with holes through the fabric patterned fabric to T-shirt, but this process is very complex, also involves many production procedure,
1 stretch mesh, making a T-shirt printing edition, first is must have a net frame, 150T screen cloth tensioner in sheet, such as printing A4 size design, network frame's diameter each big 6-10cm than pattern.
2 the design, plate-making is making good design or text, through computer and photographic technology will transform manuscript submitted, a film that will stretch mesh well in the ultraviolet light, the pattern by wire on the screen, first is clean, detergent with screen mesh cloth to clean it, and drying, the photographic plasma fell in with uniform size of coating on the net, dry after the film in cafes, close, through the proper time of photographic box, and then rinse with water and printed t-shirts pattern is carved on the screen, through the parched, printed t-shirts, net edition is completed.
3, a net edition, we T-shirt printing can be started, first put nets version of quadrilateral with tape sealing side ink searches to 賍 T-shirt on fabric, with butterfly clamp half-tone fixing it, to spread stamp-pad stamp-pad T-shirt, will half-tone pattern and T-shirt, ink pour into position alignment with scraper, ink, from far. Zhang to close out forcibly scraper, pattern print to T-shirt. T-shirt printing!
 
Hot stamping T-shirt
Hot stamping T-shirt, is to design good design, through the heat-transfer machine, printing pressure on t-shirts.
1, the T-shirt design layouts in printing presses through sheet,
2, the printed on printing design accurate paving T-shirt,
3, with constant around 180 degrees, good thermal pressure plate design about 2 minutes, remove hot plate printing paper, tear turned, stamping T-shirt success.
 
T-shirt printing technology of several questions and answers
T-shirt printing printing industry is the popular process, because in printed t-shirts or other objects in the photo printing effects, are favored by consumers, especially the printed t-shirts, gifts such small batch of products stoneware mug, are very popular. Below are a few technical question and answer session, please as reference, and please correct.
A T-shirt printing solutions, did not feel the heat up paper
Ii. Thermal paper and hot sublimation paper what differences are printed in what it
Third, what should use hot ink printing ink, what is still soup with ink painting in the above picture print t-shirts, use what brands
Four, the paper some points of cold hot tear, what kind of hot tearing AW better printed is the best quality
Five, heat up the best effect. How
Sixth, the paper and pigments were reported
 
 
 
A T-shirt printing solutions, did not feel the heat up paper?
There, we will use the sublimation inkjet printing ink, and paper. The printed to have some effect
1: depends on the quality, good with ink on paper and ink temperature, time with the situation is especially good, the effect of reduction
2: paper, general painting paper can, but if there are other good things to effect the import, the effect very good, but also reduction has shortcomings, ink play after dry, and there is no easy to print out paper round. But MeiDeShui effect.
Time: 3, to grasp the general in good time, about 1 minute, and pressure right now
Ii. Thermal paper and paper what difference between thermal sublimation? What were printed on it?
Answer: thermal paper and hot sublimation of paper should be the latter is the difference between a, called sublimation paper, hot sublimation is limitation, my experience it to contain polyester fabric on the high components must be white, can give the effect. The other hot paper application is very common, T-shirt fabric basically can, but general leather fabrics is printed on. The main difference between thermal paper is printed in use dark t-shirts or light-color T-shirt.
Third, what should use hot ink printing ink, what is still soup with ink painting in the above picture print t-shirts, what brand?
Answer: this problem can see you on this thing is very understand, you ask is same, but according to the selection for ink on the customer to you, the difference is big, brunet dress and light-colored clothes ink is different, the price difference also many, homebred a lot, but not the color reduction, I used a Japanese, is printed light-colored clothes (actually means white color, sublimation ink) six more ml.
Four, the paper some points of cold hot tear, hot tear what?
The best kind of AW print quality best my experience you ask miss only on the thermal light-colored clothes. Of course is the good, cold hot tear to cool off, especially difficult after can tear off color.
Five, heat up the best effect. How
Depends on how much you want to spend, your question is basically to individual T-shirt, very simple, a computer, a plate backing machine, a EPSON printer, basically OK, some light thermal paper and ink printing paper, ink, can heat sublimation. Can do: white T-shirt can print, metal, still can print flag, kit (of course only said before the white containing polyester, it is the component high thermal sublimate the two front of hot metal plate is also sublimate)
Sixth, the paper and pigments were reported
The white T-shirt printing paper hot tear is like in the $20 a, especially good jie, cold strip cheaper. The paper is printed hot sublimation ink printing paper, a pack of 100, also a few more than $200, good color reduction, twenty yuan a very well. The ink was dry is imported from Japan, 1 piece eight one milliliter。

無煙香港 t恤設計比賽,t恤批發,親子裝 t 恤,t恤設計,印t恤,團體t恤訂做,態度 t 恤,中國加油t恤,t 恤轉印紙

(共0條評論)用戶評論

用戶名: 匿名用戶
E-mail:
評價等級:
評論內容:
驗證碼: captcha
更多>>熱銷商品